Page 1 of 2

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK304  
X Pre-opening
    Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  ARBY'S/LOVE'S TRAVEL STOP #395 Address  3407 S STATE ROAD 45/52
Owner or Operator   LOVE'S TRAVEL STOPS & COUNTRY STOPS City   KANKAKEE Zip Code   60901
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
  
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
  
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
  
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
 
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
  
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
X
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
  
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   Quat ppm                   Dishwasher Temperature   °F or label
Food Temperatures:   No food on premises at time of inspection. Cooling/heating unit temperatures: walk-in cooler 37.5, walk-in freezer 14.5, Garland oven 1 184.5, Garland oven 2 272.5, small freezer 25.5, 3-door prep cooler 35, 2-door prep cooler 36, Sliding door cooler near registers 39, Glass front cooler near registers 39
 
General Comments
Upon receipt of the completed Food Service Establishment Referral Form, this facility is hereby allowed to operate under authority of the Kankakee County Health Department. 
Report and Instructions Received By   Jeffery A. Ashcraft /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/02/2011 Time In  9:00 AM Time Out  10:00 AM Sanitation Score  97 (100 Minus Demerits)
By  Bryan Kennedy (Sanitarian) Adjusted Score  97  
 
Page 2 of 2

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK304  
X Pre-opening
    Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  ARBY'S/LOVE'S TRAVEL STOP #395 Address  3407 S STATE ROAD 45/52
Owner or Operator   LOVE'S TRAVEL STOPS & COUNTRY STOPS City   KANKAKEE Zip Code   60901
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*45  Provide proof of at least one more certified food handler within 90 days of opening. Next Inspection
32  Observed no soap at the handsinks. Provide for all handsinks to have supply of soap and paper towels to assure that proper handwashing occurs. Before Opening
37  Observed the following wall/ceilings area(s) to be unfinished: ceiling tiles removed above drive through and in dining area and missing cover on drive through electrical access panel. Provide for all walls and ceilings to be smooth, easily cleanable, non-absorbent, durable, and light colored and be maintained in good repair. Before Opening
     
     
     
     
     
     
     
     
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   Jeffery A. Ashcraft /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/02/2011 Time In  9:00 AM Time Out  10:00 AM Sanitation Score  97 (100 Minus Demerits)
By  Bryan Kennedy (Sanitarian) Adjusted Score  97